Audi 100

1982-1990 of release




Audi 100
+ 1.1. Controls and devices
+ 2. Technical characteristics
+ 3. Engines
+ 4. Cooling system
+ 5. An exhaust system
+ 6. The power supply system
+ 7. Transmission
+ 8. A running gear
- 9. A steering
   9.1. A technical characteristics
   9.2. A steering wheel
   - 9.3. A steering column
      9.3.1. A steering column with system of passive safety PROCON-TEN
   9.4. The steering mechanism
   9.5. Adjustment of the mechanism of a steering
   9.6. Steering draught
   9.7. The pump of the hydraulic booster of a steering
   9.8. Check of pressure of forcing of the pump of the hydraulic booster of a steering
   9.9. Prorolling of system of the hydraulic booster of a steering
   9.10. A privodnoj belt of the pump of the hydraulic booster
+ 10. Brake system
+ 11. A body
+ 12. An electric equipment





9.3.1. A steering column with system of passive safety PROCON-TEN
THE GENERAL DATA

Column of a steering with system of passive safety "PROGAME-TEN"

1 – a shaft driving gear wheels of the mechanism of a steering;
2 – an arm;
3 – a bolt;
4, 5 – adjusting washers;
6 – a spring;
7 – a pipe;
8 – a cable;
9 – a steering shaft;
10 – the screw;
11 – a spring ring;
12 – a flange (a steering with the hydraulic booster);
13 – the switch of ignition with the antijoy ride device;
14 – a bolt;
15 – a flange (a steering without the hydraulic booster);
16 – a collar;
17 – a bolt;
18 – a nut

Removal

PERFORMANCE ORDER
1. To disconnect a wire from "the minus" plug of the storage battery.
2. To remove a steering wheel (subsection 9.2 see).
3. To weaken fastening подрулевых switches through an aperture located from below in a casing подрулевых of switches. To remove подрулевые switches from a pipe of a steering column, having disconnected Pads with wires.
4. To turn out screws of fastening and to remove the bottom shelf from outside the driver.
5. To remove a combination of devices (subsection 12.1.5.15 see).
6. To remove Blower for blowing feet of the driver.
7. To disconnect a cable from a shaft of a steering column.
8. Through an aperture in the panel of a combination of devices to turn on the bolt of fastening of the case of the switch (lock) of ignition with internal шестигранником.
9. To turn away a bolt of fastening of a collar, having disconnected a shaft of a steering column from a shaft driving gear wheels of the mechanism of a steering. On models with a steering column without the hydraulic booster preliminary to shift a protective casing.
10. To turn on two nuts and to take out two bolts of fastening of a steering column to an arm.
11. To lower an a bit steering column and to remove the case of the switch of ignition, having disconnected from it Pads with wires.
12. To take out a steering column through an aperture in the panel of devices.

Installation

PERFORMANCE ORDER
1. To establish a steering column upside-down.
2. Before connection of a shaft of a steering column with shaft driving gear wheels of the mechanism of a steering to insert into the switch of ignition a key and to disconnect the antijoy ride device.
3. A bolt of fastening of a collar to tighten the moment 25 Н·м (2,5 кгс·м), and two bolts of fastening of a steering column – the moment 35 Н·м (3,5 кгс·м).
4. Before steering wheel installation to establish a spring with adjusting washers if they acted in film at dismantle.